2017 Chevrolet Silverado 1500

Driving home on the interstate my truck started making a knocking sound and the vehicle would shake over 45 miles an hour. We took to a dealer that said the lifters were bad, and potentially caused damage to the cam shaft. There was no warranty. I asked how this happens under 60,000 miles and was told it’s just part failure. And with the 6.2 engines, it’s a known occurrence. I then see that Chevy 6.2L engines for earlier years had a recall for this same issue but our 2017 was excluded. The dealer quoted $10,500 for repair. But we found a local shop that did the work for around $7500.

NHTSA Safety Complaint To: National Highway Traffic Safety Administration (NHTSA) Regarding: Vehicle Safety Hazard / Fraudulent Repairs on 2017 Chevrolet Silverado VIN: [XXX] To Whom It May Concern, I am writing to file an emergency vehicle safety complaint regarding a 2017 Chevrolet Silverado, VIN [XXX], purchased on XXX. Huntley Ford performed unauthorized, fraudulent, and unsafe repairs that resulted in the vehicle being returned to me as an active fire hazard, directly violating federal motor vehicle safety expectations. Huntley Ford forced a salvage engine onto the vehicle, stripped me of my repair rights, and intentionally cleared dashboard error codes to mask severe, systemic mechanical defects. Following an engine replacement, transmission replacement, and catalytic converter replacement, I took the vehicle to Sunrise Chevrolet for inspection. The technician at Sunrise Chevrolet discovered that the vehicle was actively burning fluid onto the alternator. The technician explicitly stated that the vehicle was a fire hazard and that there was an emergency safety brake problem, and brakes. Huntley Ford knowingly delivered a structurally compromised and life-threatening vehicle. I request a full investigation into Huntley Ford’s repair safety practices to protect the public from further hazardous non-compliance. I have a 16 page paper trail Word document letter proving Huntley Ford committed auto fraud, has practiced illegal practices, lied, sold us a truck that they cleared codes, after only a few months full transmission, c. converter replacement, engine, and did not fix the truck properly still, returned it back to us when they knew it was not ok, lied, cleared codes, we brought our own scanner, they lied again, said the codes just needed to be cleared. When we notified [XXX], Huntley Ford's repair manager, he did nothing. Sincerely, [XXX]/[XXX] ________________________________________ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle would not shift through gears while driving. Torque converter shudder. Dealer found excessive metal in trans pan. Had to replace transmission. Vehicle had 107, 000 miles. Almost $5700 to replace transmission.

The contact owns a 2017 Chevrolet Silverado 1500. The contact stated that while driving 60 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended and the vehicle lost power. The contact merged onto the right side of the road, turned off and restarted the vehicle and the vehicle worked as intended; however, after driving fifteen miles down the road, the failure persisted. A dealer was contacted. The vehicle was not taken to an independent mechanic or dealer to be diagnosed. The contact stated that the failure had occurred on several occasions. The transmission was replaced, and the vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 113,800.

Torque converter clutch failed and sent metal chips through the transmission causing the transmission to fall and made the truck not drivable. The check engine light came on a few hours before the transmission finally gave out. The transmission would not shift out of first gear. We were on a family trip to [XXX] from [XXX] and this left us stranded with three kids in the truck on the side of the road. When I took the truck to the shop they asked several other transmission shops if they had seen this issue and they all confirmed they did with the same truck and the best case is to rebuild the transmission instead of replacing the just the torque converter clutch due to the amount of damage it did. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A well known issue with the torque converter failing due to poor manufacturing and design. Allowing debris to enter the filter system due to the torque converter falling apart. Causing astronomical amounts in repair costs

Transmission is hunting for gear when decelerating. Back and forth it tries to change gear. Just started. I have 64,000 miles on the truck. At 22,000 it started shuddering and the fluid was changed which corrected the issue then. At 53,000 the shudder returned and I paid the dealerdealership to replace the torque converter. Now 12,000 miles later I'm having a shifting issue. This Transmission seems to be problematic.

Interstate driving when I was required to brake quickly. Truck aggressively pulled to the right nearly colliding with another vehicle. There was a recall out for the very same thing on later model Z71 Chevy trucks. It seems I bought one that has quirks from earlier and later model vehicles. Owner manuals are not much help in these areas. Perhaps you can shed some light on this problem.