2021 Jeep Grand Cherokee

September 1: The vehicle triggered diagnostic trouble code P0306 (Cylinder 6 Misfire). It was immediately taken to an independent mechanic where the spark plugs were replaced to address the misfire. September 30: The engine suddenly refused to crank or start. The vehicle was towed back to the independent mechanic. The technician diagnosed a completely blown starter motor and noted thick white smoke billowing from the tailpipe upon replacement. Further testing revealed that engine coolant had flooded into Cylinder 6. Present: The vehicle was towed to an authorized Jeep Dealership for a comprehensive engine teardown. The dealership technicians confirmed that both the cylinder head and the engine block deck are permanently warped due to extreme localized thermal stress. Dealership advised coolant was not low and no codes on the computer to show that there was overheating occurring. All oil changes were done at the dealership and stellantis don't want to help with the replacement of the engine goodwill offered 10,500 digital imaging says no my fault I drove it overheating Coolant not low per dealership and no lights how was I to know it was overheating

The contact owns a 2021 Jeep Grand Cherokee. The contact stated that while accelerating from a stop light and making a right turn, the steering wheel became difficult to turn. The vehicle was parked immediately, and a tow truck was dispatched to the scene. The vehicle was towed to the dealer for diagnostic testing, and it was determined that the power transfer unit (PTU) and module failed and required replacement. The contact was informed that the replacement parts were on backorder. The manufacturer was notified of the failure. The failure mileage was 111,000.

The contact owns a 2021 Jeep Grand Cherokee. The contact stated that while driving 70 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended and the vehicle jerked abnormally. The vehicle was taken to the dealer; however, the failure was not duplicated. The failure was a persistent failure. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that there were metal shavings inside the oil pan. The contact was informed that the transmission needed to be replaced. The vehicle was being repaired. The manufacturer was contacted and made aware of the failure. The failure mileage was approximately 65,000.

Oil Filter Housing/Oil Cooler Failure Causing Oil and Coolant Contamination, Serpentine Belt Failure, and Engine Overheating My 2021 Jeep Grand Cherokee Laredo E, equipped with the 3.6L Pentastar V6 engine, has developed a significant oil leak originating from the oil filter housing/oil cooler assembly. A mechanic has identified this assembly as the source of the oil leak and confirmed that its failure is allowing engine oil to mix with the coolant. In addition to internal oil and coolant contamination, engine oil is leaking externally onto surrounding engine components, potentially including the serpentine belt and pulley system. The vehicle recently experienced a complete serpentine belt failure while driving, resulting in engine overheating and requiring me to pull over immediately to prevent additional engine damage. I am concerned that oil leaking from the housing assembly may have contributed to the premature deterioration and failure of the serpentine belt. The oil contamination of the cooling system presents additional safety concerns, including reduced cooling efficiency, damage to cooling system components, and the possibility of severe engine damage or unexpected vehicle disablement. The combined risks of external oil leakage, internal coolant contamination, serpentine belt failure, and engine overheating create a potentially dangerous situation, particularly during highway driving. I am concerned that the oil filter housing/oil cooler assembly may have an underlying design or manufacturing defect. I am requesting that NHTSA investigate this issue in 2021 Jeep Grand Cherokee vehicles equipped with the 3.6L Pentastar engine and determine whether a safety recall or other corrective action is warranted.

Suspected Right-Rear Brake Caliper Failure Resulting in Sudden Vehicle Stop Vehicle: 2021 Jeep Grand Cherokee Overland 4x4 Incident date: [XXX] Location: Honolulu, Hawaii Approximate mileage: 64,000 miles Affected component: Right-rear brake caliper assembly On [XXX], while traveling approximately 5 mph, my 2021 Jeep Grand Cherokee experienced a sudden, violent mechanical jolt. The vehicle abruptly stopped, jerking forward and backward with substantial force. When I attempted to accelerate again, the vehicle felt physically restrained, as though something was preventing the wheel from rotating. The vehicle would not drive forward normally, and the AutoPark system engaged under certain conditions. After exiting the vehicle, I discovered a large bolt marked with an “M” lying in the roadway. I initially did not realize it belonged to my vehicle. The responding tow truck operator later identified the bolt as associated with the right-rear brake assembly. During his inspection, the tow truck operator discovered that the right-rear brake caliper was displaced and movable near the wheel. He repositioned the assembly sufficiently to facilitate towing the vehicle to Cutter Jeep in Pearl City, Hawaii. The vehicle’s front and rear brake pads and rotors had previously been replaced on [XXX], at Wolfchase Chrysler Dodge Jeep Ram in Tennessee using genuine Mopar parts. The vehicle had approximately 50,006 miles at that service. The dealership confirmed a two-year parts warranty in writing. The vehicle also underwent routine maintenance at Cutter Jeep on June 26, 2026. I am extremely concerned that this mechanical failure caused my vehicle to stop abruptly at very low speed. Had the same failure occurred while traveling at highway speed, it could potentially have resulted in a serious loss-of-control collision. I am requesting that NHTSA evaluate this incident as a potential vehicle safety defect involving the right-rear brake caliper mounti INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle: 2021 Jeep Grand Cherokee Overland, 3.6L V6 Incident Date: [XXX] Location: [XXX] Safety Complaint: On [XXX], while driving my 2021 Jeep Grand Cherokee Overland on [XXX], the vehicle suddenly lost accelerator response while traveling on the highway. The engine initially remained running, but pressing the accelerator pedal produced no response. Multiple warning indicators illuminated simultaneously, including the electronic throttle control, ABS, traction control, airbag, and four-wheel-drive systems. The vehicle also exhibited unusual electrical behavior, including unexpected activation of the high-beam headlights. The vehicle subsequently became completely inoperable and would no longer crank or start. The sudden loss of propulsion while traveling in highway traffic created a serious safety hazard and placed me at risk of a collision. This incident follows an extensive history of significant mechanical failures and repairs to this vehicle, including: Replacement of the cylinder head following repeated overheating and engine misfires. Complete transmission replacement following transmission-related failures. Replacement of the radiator and cooling fan assembly TWICE within approximately one year, most recently during a trip to North Carolina. Additional mechanical concerns, including a camshaft-related diagnostic trouble code. Despite these major component replacements, the vehicle continues to experience serious reliability and operational failures. These repeated problems have occurred despite attempts to address them through dealership repairs and manufacturer warranty assistance. Stellantis previously extended the vehicle's warranty as a goodwill gesture following earlier issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving 65 MPH on a highway in high traffic and the Fuel propulsion system failed without any lights or warning. It just stop responding to accerlation. It was extremely dangerous and CDOT had to come rescue us. We are lucky we were not hurt or killed. The 2021 Jeep Grand Cherokee is only 5 years old and has 46,000 miles on it. The fuel pump needs a complete replacement. It is months out of warranty but still there should be 50,000-100,000 miles left on this part.

The driver’s seatbelt sensor constantly goes off as not detecting that the seatbelt is buckled, while driving; this causes the alarm to continuously beep and also disables the airbag. Aside from the seatbelt issue, there is a standalone airbag issue that has been detected by the car’s health report multiple times. The drive shaft is also defective, causing the car to shake when the car hits 73 mph. The auto stop/start also disables on its own. I have taken it to the dealership to get all of this fixed but all issues have persisted. There are active recalls on these issues for other 2021 Jeep Grand Cherokees but they are not attached to my vehicle even though my vehicle has the same recall issues.